Abstract  Carbon nanotubes (CNTs) are being investigated for a variety of biomedical applications. Despite numerous studies, the pathways by which carbon nanotubes enter cells and their subsequent intracellular trafficking and distribution remain poorly determined. Here, we use 3-D electron tomography techniques that offer optimum enhancement of contrast between carbon nanotubes and the plasma membrane to investigate the mechanisms involved in the cellular uptake of shortened, functionalised multi-walled carbon nanotubes (MWNT-NH(3)(+)). Both human lung epithelial (A549) cells, that are almost incapable of phagocytosis and primary macrophages, capable of extremely efficient phagocytosis, were used. We observed that MWNT-NH(3)(+) were internalised in both phagocytic and non-phagocytic cells by any one of three mechanisms: (a) individually via membrane wrapping; (b) individually by direct membrane translocation; and (c) in clusters within vesicular compartments. At early time points following intracellular translocation, we noticed accumulation of nanotube material within various intracellular compartments, while a long-term (14-day) study using primary human macrophages revealed that MWNT-NH(3)(+) were able to escape vesicular (phagosome) entrapment by translocating directly into the cytoplasm.

Abstract  Carbon nanotubes are shaped like fibres and can stimulate inflammation at the surface of the peritoneum when injected into the abdominal cavity of mice, raising concerns that inhaled nanotubes may cause pleural fibrosis and/or mesothelioma. Here, we show that multiwalled carbon nanotubes reach the subpleura in mice after a single inhalation exposure of 30 mg m(-3) for 6 h. Nanotubes were embedded in the subpleural wall and within subpleural macrophages. Mononuclear cell aggregates on the pleural surface increased in number and size after 1 day and nanotube-containing macrophages were observed within these foci. Subpleural fibrosis unique to this form of nanotubes increased after 2 and 6 weeks following inhalation. None of these effects was seen in mice that inhaled carbon black nanoparticles or a lower dose of nanotubes (1 mg m(-3)). This work suggests that minimizing inhalation of nanotubes during handling is prudent until further long-term assessments are conducted.

Abstract  Modifications of carbon nanotubes (CNTs) for different applications may change their physicochemical properties such as surface charge. Assessments of the extent to which such modifications influence CNT ecotoxicity, accumulation, and elimination behaviors are needed to understand potential environmental risks these variously modified nanoparticles may pose. We have modified carbon-14 labeled multi-walled carbon nanotubes (MWNTs) with polyethyleneimine (PEI) surface coatings to increase their aqueous stability and to give them positive, negative, or neutral surface charges. Uptake and elimination behaviors of Daphnia magna exposed to PEI-coated and acid-modified MWNTs at concentrations of approximately 25 and 250 μg/L were quantified. PEI surface coatings did not appear to substantially impact nanotube accumulation or elimination rates. Although the PEI-modified nanotubes exhibited enhanced stability in aqueous solutions, they appeared to aggregate in the guts of D. magna in a manner similar to acid-treated nanotubes. The MWNTs were almost entirely eliminated by Daphnia fed algae during a 48 h elimination experiment, whereas elimination without feeding was typically minimal. Finally, PEI coatings increased MWNT toxicities, though this trend corresponded to the size of the PEI coatings, not their surface charges.

Abstract  Carboxylated carbon nanotubes stand as the most promising nanovectors for biomedical and pharmaceutical applications due to their ease of covalent conjugation with eclectic functional molecules including therapeutic drugs, proteins, and oligonucleotides. In the present study, we attempt to investigate how the toxicity of acid-oxidized multiwalled carbon nanotubes (MWCNTs) can be tweaked by altering their degree of functionalization and correlate the toxicity trend with their biodistribution profile. In line with that rationale, mice were exposed to 10 mg/kg of pristine (p) and acid-oxidized (f) MWCNTs with varying degrees of carboxylation through a single dose of intravenous injection. Thereafter, extensive toxicity studies were carried out to comprehend the short-term (7 day) and long-term (28 day) impact of p- and various f-MWCNT preparations on the physiology of healthy mice. Pristine MWCNTs with a high aspect ratio, surface hydrophobicity, and metallic impurities were found to induce significant hepatotoxicity and oxidative damage in mice, albeit the damage was recovered after 28 days of treatment. Conversely, acid-oxidized carboxylated CNTs with shorter lengths, hydrophilic surfaces, and high aqueous dispersibility proved to be less toxic and more biocompatible than their pristine counterparts. A thorough scrutiny of various biochemical parameters, inflammation indexes, and histopathological examination of liver indicated that toxicity of MWCNTs systematically decreased with the increased functionalization density. The degree of shortening and functionalization achieved by refluxing p-MWCNTs with strong mineral acids for 4 h were sufficient to render the CNTs completely hydrophilic and biocompatible, while inducing minimal hepatic accumulation and inflammation. Quantitative biodistribution studies in mice, intravenously injected with Tc-99m labeled MWCNTs, clearly designated that clearance of CNTs from reticuloendothelial system (RES) organs such as liver, spleen, and lungs was critically functionalization density dependent. Well-individualized MWCNTs with shorter lengths (<500 nm) and higher degrees of oxidation (surface carboxyl density >3 μmol/mg) were not retained in any of the RES organs and rapidly cleared out from the systematic circulation through renal excretion route without inducing any obvious nephrotoxicity. As both p- and f-MWCNT-treated groups were devoid of any obvious nephrotoxicity, CNTs with larger dimensions and lower degrees of functionalization, which fail to clear out from the body via renal excretion route, were thought to be excreted via biliary pathway in faeces.

Abstract  It is expected that the rapid expansion of nanotechnology will bring many potential benefits. However, initial investigations have demonstrated that nanomaterials may adversely affect human health and the environment. By increasing the alication of nanoparticles, protection of the human respiratory system from exposure to airborne nanoparticles and ultrafine particulates has become an emerging health concern. Available research has demonstrated an association between exposure to ambient airborne particulates and ultrafine particles and various adverse heath effects including increased morbidity and mortality. Nanomaterial structures are more likely to be toxic than the same materials of conventional sized samples and can be inhaled more deeply into the lungs. While the respiratory tract is considered as the primary target organ for inhaled nanoparticles, recent research has demonstrated that extrapulmonary organs are also affected. The very small size distribution and large surface area of nanoparticles available to undergo reactions may play a significant role in nanotoxicity, yet very little is known about their interactions with biological systems. This review explores the possible underlying toxicity mechanisms of nanoparticles following inhalational exposure. Nanoparticles differ from the same conventional material at a larger scale in physical, chemical and biological characteristics; therefore it is critical to recognize the potential risk of nanoparticle exposure using appropriate toxicity test methods. Current advances and limitations of toxicity assessment methods of nanoparticles are discussed highlighting the recent improvements of in vitro screening tools for the safety evaluation of the rapidly expanding area of nanotechnology.

Abstract  A possible teratogenicity of multi-wall carbon nanotube (MWCNT) was assessed using ICR mice. MWCNTs were suspended in 2% carboxymethyl cellulose and given intraperitoneally or intra-tracheally to pregnant ICR mice on day 9 of the gestation. All fetuses were removed from the uterus on day 18 of the gestation, and were examined for external and skeletal anomalies. In the intraperitoneal study, various types of malformation were observed in all MWCNT-treated groups (2, 3, 4 and 5 mg/kg body weight, intraperitoneal). In contrast, such malformations were observed in groups given 4 or 5 mg/kg body weight, but not in that treated with 3 mg/kg in the intratracheal study. In either study, the number of litters having fetuses with external malformation and that of litters having fetuses with skeletal malformations were both increased in proportion to the doses of MWCNT. The present results are the first to report that MWCNT possesses the teratogenicity at least under the present experimental conditions. Mechanism(s) to result such malformations is yet unclear and further experiment is necessary.

Abstract  Environmental protection in the United States has reached a critical juncture. It has become clear that to address the complex and interrelated environmental challenges we face, we must augment our traditional approaches. The scientific community must build upon its deep understanding of risk assessment, risk management, and reductionism with tools, technologies, insights and approaches to pursue sustainability. The U.S. Environmental Protection Agency (EPA) has recognized this need for systemic change by implementing a new research paradigm called "The Path Forward." This paper outlines the principles of the Path Forward and the actions taken since 2010 to align EPA's research efforts with the goal of sustainability.

Abstract  Multi-walled carbon nanotubes (MWNTs) were grafted with poly (acrylic acid), and subsequently coated with a close-packed layer of silica nanospheres, namely SiO2-g-MWNTs. Such blob-like MWNTs/silica nanospheres hybrids were introduced into poly (methyl methacrylate) (PMMA) as a kind of flame retardant. From determinations of thermogravimetric analysis and cone calorimeter tests, it was indicated that the SiO2-g-MWNTs not only increased the initial degradation temperature and the maximum weight loss rate temperature of PMMA, but also decreased the peak of heat release rate. Observation using scanning electron microscopy revealed that the silica nanospheres on the surface of MWNTs strengthened the protective network layer during combustion.

Abstract  Because of their outstanding properties, carbon nanotubes (CNTs) are being assessed for inclusion in many manufactured products. Due to their massive production and growing number of potential applications, the impact of CNTs on the environment must be taken into consideration. The present investigation evaluates the ecotoxicological potential of double-walled carbon nanotubes (DWNTs) in the amphibian larvae Xenopus laevis at a large range of concentrations in water (from 10 to 500 mgL(-1)). Acute toxicity and genotoxicity were analysed after 12 days of static exposure in laboratory conditions. Acute toxicity was evaluated according to the mortality and the growth of larvae. The genotoxic effects were analysed by scoring the micronucleated erythrocytes of the circulating blood of larvae according to the International Standard micronucleus assay. Moreover, histological preparations of larval intestine were prepared after 12 days of exposure for observation using optical and transmission electron microscopy (TEM). Finally, the intestine of an exposed larva was prepared on a slide for analyse by Raman imaging. The results showed no genotoxicity in erythrocytes of larvae exposed to DWNTs in water, but acute toxicity at every concentration of DWNTs studied which was related to physical blockage of the gills and/or digestive tract. Indeed, black masses suggesting the presence of CNTs were observed inside the intestine using optical microscopy and TEM, and confirmed by Raman spectroscopy analysis. Assessing the risks of CNTs requires better understanding, especially including mechanistic and environmental investigations.

Abstract  Soluble carbon nanotubes show promise as materials for in vivo delivery and imaging applications. Several reports have described the in vivo toxicity of carbon nanotubes, but their effects on male reproduction have not been examined. Here, we show that repeated intravenous injections of water-soluble multiwalled carbon nanotubes into male mice can cause reversible testis damage without affecting fertility. Nanotubes accumulated in the testes, generated oxidative stress and decreased the thickness of the seminiferous epithelium in the testis at day 15, but the damage was repaired at 60 and 90 days. The quantity, quality and integrity of the sperm and the levels of three major sex hormones were not significantly affected throughout the 90-day period. The fertility of treated male mice was unaffected; the pregnancy rate and delivery success of female mice that mated with the treated male mice did not differ from those that mated with untreated male mice.

Abstract  A diverse array of carbon nanomaterials (NMs), including fullerene, carbon nanotubes (CNTs), graphene, nanodiamonds, and carbon nanoparticles, have been discovered and widely applied in a variety of industries. Carbon NMs have been detected in the environment and have a strong possibility of entering the human body. The safety of carbon NMs has thus become a serious concern in academia and society. To achieve strict biosafety assessments, researchers need to fully understand the effects and fates of NMs in the human body, including information about absorption, distribution, metabolism, excretion, and toxicity (ADME/T). To acquire the ADME data, researchers must quantify NMs, but carbon NMs are very difficult to quantify in vivo. The carbon background in a typical biological system is high, particularly compared with the much lower concentration of carbon NMs. Moreover, carbon NMs lack a specific detection signal. Therefore, isotopic labeling, with its high sensitivity and specificity, is the first choice to quantify carbon NMs in vivo. Previously, researchers have used many isotopes, including (13)C, (14)C, (125)I, (131)I, (3)H, (64)Cu, (111)In, (86)Y, (99m)Tc, and (67)Ga, to label carbon NMs. We used these isotopic labeling methods to study the ADME of carbon NMs via different exposure pathways in animal models. Except for the metabolism of carbon NMs, which has seldom been investigated, significant amounts of data have been reported on the in vivo absorption, distribution, excretion, and toxicity of carbon NMs, which have revealed characteristic behaviors of carbon NMs, such as reticuloendothelial system (RES) capture. However, the complexity of the biological systems and diverse preparation and functionalization of the same carbon NMs have led to inconsistent results across different studies. Therefore, the data obtained so far have not provided a compatible and systematic profile of biosafety. Further efforts are needed to address these problems. In this Account, we review the in vivo quantification methods of carbon NMs, focusing on isotopic labeling and tracing methods, and summarize the related labeling, purification, bio-sampling, and detection of carbon NMs. We also address the advantages, applicable situations, and limits of various labeling and tracing methods and propose guidelines for choosing suitable labeling methods. A collective analysis of the ADME information on various carbon NMs in vivo would provide general principles for understanding the fate of carbon NMs and the effects of chemical functionalization and aggregation of carbon NMs on their ADME/T in vivo and their implications in nanotoxicology and biosafety evaluations.

Abstract  Many potential applications of carbon nanotubes (CNTs) require various physicochemical modifications prior to use, suggesting that nanotubes having varied properties may pose risks in ecosystems. A means for estimating bioaccumulation potentials of variously modified CNTs for incorporation in predictive fate models would be highly valuable. An approach commonly used for sparingly soluble organic contaminants, and previously suggested for use as well with carbonaceous nanomaterials, involves measurement of their octanol–water partitioning coefficient (KOW) values. To test the applicability of this approach, a methodology was developed to measure apparent octanol–water distribution behaviors for purified multi-walled carbon nanotubes and those acid treated. Substantial differences in apparent distribution coefficients between the two types of CNTs were observed, but these differences did not influence accumulation by either earthworms (Eisenia foetida) or oligochaetes (Lumbriculus variegatus), both of which showed minimal nanotube uptake for both types of nanotubes. The results suggest that traditional distribution behavior-based KOW approaches are likely not appropriate for predicting CNT bioaccumulation.

Abstract  The interaction of multi-walled carbon nanotubes (MWNTs) with living unicellular protozoan Stylonychia mytilus was studied. The results indicated that MWNTs were ingested largely by Stylonychia mytilus. Distribution of MWNTs in the cells, redistribution during dividing process of the cells, and excretion from the cells were observed successfully with optical microscope. The dependence of viability of Stylonychia mytilus was determined on the concentration of MWNTs, ranging from 0.1 microg/ml to 200 microg/ml. It was found that exposure of Stylonychia mytilus to the MWNTs with concentration higher than 1.0 microg/ml induced a dose-dependent growth inhibition to the cells and the damage occurred, by fluorescence microscopy, on the macronucleus and external membrane of the cells. The ultrastructure change by electron microscope revealed that the MWNTs exclusively localized to the mitochondria of the cells. It was proposed that the damage of macronucleus, micronucleus, and membrane of the cells, as well as growth inhibition of the cells might be a result of the damage of mitochondria, following this exclusive localization. Our finding provides important information on the bio-security of MWNTs and their migration in aqueous environment.

Abstract  Background: Carbon nanotubes represent a class of nanomaterials having broad application potentials and documented cellular uptake and ecotoxicological effects that raise the possibility that they may bioaccumulate in living organisms. Objectives: Radioactively labeled nanotubes were synthesized using a novel methane chemical vapor deposition procedure. Single-walled carbon nanotubes (SWNTs), multiwalled carbon nanotubes (MWNTs), and pyrene were spiked to sediment samples, and the respective uptake and depuration of these nanotubes and pyrene were assessed by the oligochaete, Lumbriculus variegatus. Results: (14)C-labeled carbon nanotubes were developed for these experiments to overcome significant previous limitations for quantifying nanotube materials in environmental and biological media. Biota-sediment accumulation factors for SWNTs and MWNTs were observed to be almost an order of magnitude lower than those for pyrene, a four-ringed polycyclic aromatic hydrocarbon (PAH). The depuration behaviors of the oligochaete suggested that the nanotubes detected in these organisms were associated with sediments remaining in the organism guts and not absorbed into cellular tissues as was the pyrene. The results suggest that, unlike PAHs, purified carbon nanotubes do not readily absorb into organism tissues.

Abstract  Carbon nanotubes (CNTs) are currently incorporated into various consumer products, and numerous new applications and products containing CNTs are expected in the future. The potential for negative effects caused by CNT release into the environment is a prominent concern and numerous research projects have investigated possible environmental release pathways, fate, and toxicity. However, this expanding body of literature has not yet been systematically reviewed. Our objective is to critically review this literature to identify emerging trends as well as persistent knowledge gaps on these topics. Specifically, we examine the release of CNTs from polymeric products, removal in wastewater treatment systems, transport through surface and subsurface media, aggregation behaviors, interactions with soil and sediment particles, potential transformations and degradation, and their potential ecotoxicity in soil, sediment, and aquatic ecosystems. One major limitation in the current literature is quantifying CNT masses in relevant media (polymers, tissues, soils, and sediments). Important new directions include developing mechanistic models for CNT release from composites and understanding CNT transport in more complex and environmentally realistic systems such as heteroaggregation with natural colloids and transport of nanoparticles in a range of soils.

Abstract  Background: Multi-walled carbon nanotubes (MWCNT) are new manufactured nanomaterials with a wide spectrum of commercial applications. The durability and fiber-like dimensions (mean length 3.9 um long x 49 nm diameter) of MWCNT suggest that these fibers may migrate to and have toxicity within the pleural region. To address whether the pleura received a significant and persistent exposure, C57BL/6J mice were exposed by pharyngeal aspiration to 10, 20, 40 and 80 ug MWCNT or vehicle and the distribution of MWCNT penetrations determined at 1, 7, 28 and 56 days after exposure. Following lung fixation and sectioning, morphometric methods were used to determine the distribution of MWCNT and the number of MWCNT fiber penetrations of three barriers: alveolar epithelium (alveolar penetrations), the alveolar epithelium immediately adjacent to the pleura (subpleural tissue), and visceral pleural surface (intrapleural space). Results: At 1 day 18%, 81.6% and 0.6% of the MWCNT lung burden was in the airway, the alveolar, and the subpleural regions, respectively. There was an initial, high density of penetrations into the subpleural tissue and the intrapleural space one day following aspiration which appeared to decrease due to clearance by alveolar macrophages and/or lymphatics by day 7. However, the density of penetrations increased to steady state levels in the subpleural tissue and intrapleural from day 28 - 56. At day 56 approximately 1 in every 400 fiber penetrations was in either the subpleural tissue or intrapleural space. Numerous penetrations into macrophages in the alveolar airspaces throughout the lungs were demonstrated at all times but are not included in the counts presented. Conclusions: The results document that MWCNT penetrations of alveolar macrophages, the alveolar wall, and visceral pleura are both frequent and sustained. In addition, the findings demonstrate the need to investigate the chronic toxicity of MWCNT at these sites.

Abstract  Increasing production of and application potentials for carbon nanotubes (CNTs) suggest these materials will enter soil and sediment ecosystems in significant masses in upcoming years. This may result in ecological risks, either from the presence of the CNTs themselves or, given their exceptional sorption capacities, from their effects on the fate and accumulation of concurrently present hydrophobic organic chemicals (HOCs). Here we test the influence of additions of single-walled CNTs (SWNTs) and multi-walled CNTs (MWNTs) to two different pyrene-contaminated soils on uptake of this HOC by earthworms (Eisenia foetida). The effects of nanotube additions to the soils were observed to be CNT concentration dependent, with 0.3 mg nanotubes per gram of soil having no impact, while 3.0 mg/g of SWNTs or MWNTs substantially decreased pyrene bioaccumulation from both contaminated soils. The presence of CNTs also affected pyrene elimination rates. After a 14-day exposure to pyrene-spiked soils, earthworms showed enhanced elimination rates in soils amended with 3.0 mg CNT/g but not 0.3 mg CNT/g. These results suggest that the presence of SWNTs or MWNTs in terrestrial ecosystems will have concentration-dependent effects on decreasing HOC accumulation by earthworms in a manner similar to that expected of most "hard" carbons.

Abstract  The potential impact of industrial multiwalled carbon nanotubes (MWNTs) was investigated under normalized laboratory conditions according to the International Standard micronucleus assay ISO 21427-1 for 12 days of half-static exposure to 0.1, 1, 10 and 50 mg/l of MWNTs in water. Three different end points were carried out for 12 days of exposure: mortality, growth inhibition and micronuclei induction in erythrocytes of the circulating blood of larvae. Raman spectroscopy analysis was used to study the presence of carbon nanotubes in the biological samples. Considering the high diversity of carbon nanotubes according to their different characteristics, MWNTs were analyzed in Xenopus larvae, comparatively to double-walled carbon nanotubes used in a previous study in similar conditions. Growth inhibition in larvae exposed to 50 mg/l of MWNTs was evidenced; however, no genetoxicity (micronucleus assay) was noticed, at any concentration. Carbon nanotube localization in the larvae leads to different possible hypothesis of mechanisms explaining toxicity in Xenopus.

Abstract  A series of one-dimensional column experiments was conducted to examine the effects of tube length on the transport and deposition of 4-ethoxybenzoic acid functionalized multi-wall carbon nanotubes (MWCNTs) in water-saturated porous media. Aqueous MWCNTs suspensions were prepared to yield three distributions of tube lengths; 0.02-1.3 μm (short), 0.2-7.5 μm (medium), and 0.2-21.4 μm (long). Results of the column studies showed that MWCNT retention increased with increasing tube length. Nevertheless, more than 76% of the MWCNT mass delivered to the columns was detected in effluent samples under all experimental conditions, indicating that the functionalized MWCNTs were readily transported through 40-50 mesh Ottawa sand. Examination of MWCNT length distributions in the effluent samples revealed that nanotubes with lengths greater than 8 μm were preferentially deposited. In addition, measured retention profiles exhibited the greatest MWCNT deposition near the column inlet, which was most pronounced for the long MWCNTs, and decreased sharply with travel distance. Scanning electron microscope (SEM) images showed that MWCNTs were deposited on sand surfaces over the entire column length, while larger MWCNT bundles were retained at grain intersections and near the column inlet. A mathematical model based on clean bed filtration theory (CBFT) was unable to accurately simulate the measured retention profile data, even after varying the weighting function and incorporating a nonuniform attachment rate coefficient expression. Modification of the mathematical model to account for physical straining greatly improved predictions of MWCNT retention, yielding straining rate coefficients that were four orders-of-magnitude greater than corresponding attachment rate coefficients. Taken in concert, these experimental and modeling results demonstrate the potential importance of, and need to consider, particle straining and tube length distribution when describing MWCNT transport in water-saturated porous media.